MULTIVARIATE SELECTION OF VARIABLES IN INDUSTRIAL QUALITY CONTROL:OPTIMIZING AVIATION FUEL FINAL CONTROL

This paper deals with a typical question encountered in all industrial analytical laboratories:are all thetests performed in the laboratory to characterize the final product really necessary?In this work the cross-validation technique,Procrustes rotation techniques and statistical variable selection have been used toreduce the 26 initial British Petroleum and ASTM kerosene specification tests to ten'essential'ones.Statistical as well as chemical considerations were used to select the optimum subset of original variablesto be retained from all the possible ones.     

H2O/CO2污染对煤油燃料超声速燃烧影响数值研究

在纯净空气与H₂O/ CO₂污染空气来流对比试验结果基础上,采用数值计算方法和化学动力学方法,研究了H₂O和CO₂污染组分对煤油燃料超声速燃烧的影响,获得了试验手段难以得到的燃烧室流场参数和性能数据。完成了相应的煤油燃料超声速燃烧室二维数值计算,其中匹配了进口总温、总压、马赫数、氧气摩尔分数和工作当量油气比。将数值计算结果与相应试验测量值进行了对比分析,并结合燃烧室流场数据、性能参数分析了H₂O和CO₂污染的动力学影响、以及对燃烧室性能的影响。研究表明:(1)数值计算结果与实验测量值总体上吻合,两种手段均体现了纯净空气来流时不同煤油当量油气比的燃烧室性能,并反映了一致的“污染效应”影响趋势;(2) H₂O污染、H₂O+ CO₂污染的存在降低了煤油燃料超声速燃烧室性能,体现在燃烧诱导压升、燃烧效率、流向冲量增量的下降,而且随着污染组分含量的增加,燃烧室性能下降越加显著。      

The effects of dodecylamine, kerosene and pH on batch flotation of Turkey's Tuncbilek coal

The effects of dodecylamine (DDA), kerosene and pH on the recovery of combustible matter and ash content of a lignitic coal from Tuncbilek, Turkey have been studied using a three-variable and two-level (2³) factorial experimental design. The coal sample responded favourably to batch flotation with high recoveries in excess of 95% using both kerosene and DDA respectively. The main effects of all three factors on the recovery are positive. Significance of DDA as a collector, is somewhat greater than that of kerosene, but its selectivity for ash reduction is not significant at the 95% confidence level. The pH-dependence of recovery by these collectors is opposite to each other. The DDA-induced flotation recovery is lowest at pH 9.4, an effect which has been related to precipitation of cationic species of this collector. The kerosene-induced recovery and grade of combustible matter increases with pH and this has been attributed to a better dispersion of coal and its associated clays. The two-way interaction effects are all negative at a smaller level. The main and interaction effects have been discussed on the basis of adsorption at most favourable surface sites, different modes of orientation of DDA species, competition with kerosene, and probable collecting properties of the frother used. The simultaneous effects of the two collectors on the recovery of combustible matter have been discussed at each pH value used.     

H2O/CO2污染对煤油燃料超声速燃烧影响数值研究

在纯净空气与H₂O/ CO₂污染空气来流对比试验结果基础上,采用数值计算方法和化学动力学方法,研究了H₂O和CO₂污染组分对煤油燃料超声速燃烧的影响,获得了试验手段难以得到的燃烧室流场参数和性能数据。完成了相应的煤油燃料超声速燃烧室二维数值计算,其中匹配了进口总温、总压、马赫数、氧气摩尔分数和工作当量油气比。将数值计算结果与相应试验测量值进行了对比分析,并结合燃烧室流场数据、性能参数分析了H₂O和CO₂污染的动力学影响、以及对燃烧室性能的影响。研究表明:(1)数值计算结果与实验测量值总体上吻合,两种手段均体现了纯净空气来流时不同煤油当量油气比的燃烧室性能,并反映了一致的“污染效应”影响趋势;(2) H₂O污染、H₂O+ CO₂污染的存在降低了煤油燃料超声速燃烧室性能,体现在燃烧诱导压升、燃烧效率、流向冲量增量的下降,而且随着污染组分含量的增加,燃烧室性能下降越加显著。      

The efficiency of kerosene flotation for extraction of chironomid head capsules from lake sediments samples

Kerosene, a grade mineral oil, is commonly used to extract beetles from sediment. Here, the use of kerosene to extract chironomid head capsules was tested on 10 samples from sediment of different lakes, with different organic matter content as measured by loss on ignition, and estimated ages. Our results revealed that this flotation tool is very effective in extracting either full or half chironomid head capsules. The mean extraction efficiency was 89.3 ± 8.0% with an estimated relative abundance error ranging from −1% to 1% for 46 of the 57 identified taxa. Larger chironomids (400–500 μm width), which are often full of sediment particles, have the highest relative abundance error, with a maximum of 4.3% for Corynocera oliveri-type. A canonical correspondence analysis showed that, despite this small bias, samples retrieved with the kerosene flotation do not differ from the whole sample assemblages. These results give us confidence in the use of this flotation technique for chironomid sample preparation.