Geotechnical Properties of Low Calcium and High Calcium Fly Ash

In this paper, a comparative study has been made for physical and engineering properties of low calcium and high calcium Indian fly ash. The grain size distribution of fly ash is independent of lime content. Fly ash particles of size >75 μm are mostly irregular in shape whereas finer fractions are spherical for low calcium fly ash. For high calcium fly ash, chemical and mineralogical differences have been observed for different size fractions. Compared to low calcium fly ash, optimum moisture content is low and maximum dry density is high for high calcium fly ash. Optimum moisture content is directly proportional and maximum dry density is inversely proportional to the carbon content. The mode and duration of curing have significant effect on strength and stress–strain behavior of compacted fly ash. The gain in strength with time for high calcium fly ash is very high compared to that of low calcium fly ash due to presence of reactive minerals and glassy phase.     

水泥-粉煤灰浆液在水电站隧洞灌浆中的应用

针对三叉水电站引水隧洞Ⅳ标段围岩地质条件,详细分析了水泥-粉煤灰浆液在该工程引水隧洞灌浆中的应用情况。从应用情况综合分析可以得出,隧洞灌浆采用水泥-粉煤灰浆液是可行的,完全能满足设计要求,在保证灌浆质量的前提下,可以降低部分施工成本,具有较好的推广应用价值。     

新型镁质膨胀材料的制备与性能研究

主要研究了以多种富镁矿物为原料，制备适合于大掺量粉煤灰混凝土的新型镁质膨胀材料，用以补偿大坝由于温度应力引起的收缩。通过在不同粉煤灰掺量的水泥浆体中，外掺不同比例的新型镁质膨胀材料和传统MgO膨胀剂，研究水泥浆体压蒸膨胀率的变化规律以及40℃水中长龄期养护膨胀率的变化过程及趋势。结果表明，随着膨胀材料掺量的增加，膨胀率相应增加。随着养护龄期的延长，膨胀率相应增大，到120d左右，膨胀趋于平缓。粉煤灰对传统MgO膨胀剂具有明显的抑制作用，且随着粉煤灰掺量的增加，抑制作用加强。新型镁质膨胀材料能很好的改善抑制作用，从而满足大掺量粉煤灰混凝土工程的要求。     

水热条件下利用微波加热从粉煤灰合成沸石研究

着重选用NaOH水溶液为反应前驱物, 通过改变反应温度、NaOH浓度与合成时间等参数, 在水热条件下利用微波加热直接对粉煤灰进行晶化, 合成得到了浊沸石、菱沸石、NaP1沸石3种沸石.粉煤灰转化为沸石率约15%~40%.研究表明: (1) 反应体系在15min左右即有合成沸石产生, 30min左右合成沸石转化率达到最佳; (2) 为保证沸石晶核生成和晶体的生长, 反应体系的溶液/粉煤灰比不应低于2.5; (3) 在溶液/粉煤灰比为2.5时, 应控制加热时间在30min左右.      

Laboratory study of the rates and products of the phototransformations of naphthalene adsorbed on samples of titanium dioxide,ferric oxide,muscovite, and fly ash

The photodegradation of naphthalene (NPH), chosen as a model of polynuclear aromatic pollutants, has been studied in the presence of a layer of four water-insoluble inorganic solids which can be found in the troposphere (TiO₂, Fe₂O₃, muscovite, and a fly ash sample). Direct photolysis of NPH is negligible at >340 nm. Dark adsorption of NPH on TiO₂ (mainly anatase, nonporous, 50 m² g^–1) at 293 K corresponds to a surface coverage ofca. 50% at equilibrium. Under these conditions (saturated surface), the stationary-state photocatalytic degradation reaches 0.4 molecule nm^–2 h^–1 (>340 nm, radiant fluxca. 22 mW cm^–2). Dioxygen is required and its partial pressure in air is such that the degradation is zero order in O₂. Water vapor markedly increases the rate. The other particulates have also an effect, less important than that of TiO₂, however quite noticeable with respect to surface area unit for the fly ash sample which contains 3.2% Fe₂O₃. Apart from 1,4-naphthoquinone, which is the main intermediate product in all cases, 2-naphthol, phthalide, phthaldialdehyde, phthalic acid, acetophenone, benzaldehyde, benzoic acid are also formed on dry TiO₂. Depending on their volatility, these compounds are transferred to the gas phase or remain principally adsorbed on the solid particles where they are further transformed. For instance, phthalic acid (or anhydride) and benzoic acid are generated from 1,4-naphthoquinone. Degradation mechanisms are briefly discussed.     

Valency Study of Vanadium in Stone Coal Ash of Jiangxi Province

Vanadium-bearing stone coal is a new vanadium resource;recovery ofV_2O_5 from the coal has been investigated.It has been found that a satisfactoryextraction of V_2O_5 depends on both the oxidation of V and its reaction with so-dium salt.V in the coal ash of Yushan mainly exists in two oxidation states:98％V(Ⅲ)and2％V(Ⅳ).The distribution of valency of V shows that organicmatter determines V valency at low temperatures,at about470℃,V(Ⅲ)iscompletely oxidized to V(Ⅳ);above500℃,the temperature is the most impor-tant factor for the oxidation of V .At higher temperatures no more V is oxidizedto V(Ⅴ);an equilibrium is established after92％of V is oxidized to V(Ⅴ).The roles of NaCl in the recovery of V_2O_5 from the coal ash were discussed.The best conditions for roasting are temperature750-800℃for1 h.underthe oxidation-chlorination atmosphere.When the ore:NaCl=100:10 by weight,η_roast reaches85.5％.According to the results,a flowsheet for V_2O_5 extrac-tion from coal ash has been proposed.     

处置库污泥工程特性测试研究

对某填埋场污泥库中取样的污泥进行了岩土工程特性测试,包括有机质含量、含水率、界限含水率、颗粒级配、渗透系数、压缩固结特性及抗剪强度等。试验结果表明,与常规淤泥相比,污泥库中经一段时间降解后污泥有机质含量及含水率较高,平均值分别为45%和520%;污泥在历时2 a的生物降解作用下,污泥含水率、有机质含量沿深度呈较为明显的减少趋势;污泥具有极高的压缩性,压缩系数a100-200高达7 MPa-1;污泥的固结表现为非线性大变形特性,其固结系数在10-5～10-6 cm2/s,比淤泥低1～2个数量级,固结系数随压力的增加而显著减少;污泥的抗剪强度参数较小,其黏聚力为0,内摩擦角为14.7°。有机质含量高是污泥高含水率、高液塑性指数、高压缩性,低渗透性、低固结系数及低抗剪强度的本质原因。以上成果可为污泥库的固化处置、稳定分析等提供必要的参数。     

粉煤灰制备硫铝酸钙-阿利特水泥熟料的研究

以粉煤灰为主要原料, CaF2为矿化剂,设计MG和MS值,控制CaO和CaSO4含量,分别在1 150、1 200、1 250、1 300和1 350℃温度下烧制高胶凝性硫铝酸钙-阿利特复合矿相水泥熟料.运用X射线粉晶衍射(XRD)和扫描电镜(SEM)等手段,研究原料配方和煅烧温度对熟料物相组成的影响,对熟料物相形成的反应历程作了探讨.实验结果表明,在1-300℃,当MG=1.05、MS =0.95时,形成较理想的熟料,物相组成约为C4A3-S 58.73%,C3S 23.99%,C2S 2.87%,C11A7·CaF2/C12A7 14.07 %,f-CaO 0.35%.熟料中主要物相硫铝酸钙晶体呈菱形十二面体,发育完整,形态规则,颗粒大小约为1～3 μm;阿利特(C3S)相物相为板状六角形,晶体发育相对细小.     

攀钢发电厂麻地湾灰场初期坝及堆积灰体工程地质特征研究

分级分期灰渣筑坝是近年发展起来的山谷贮灰场建设的一种新型技术,是为了满足燃煤电厂贮灰年限和调节洪水的要求的一种新型设计.为满足分级分期灰渣筑坝的设计要求,分析评价初期坝的稳定性与先期粉煤灰灰体堆积特征是构筑分级子坝的重要基础.本文通过水文地质及工程地质调查与岩土工程勘察探讨了麻地湾灰场子坝加高所涉及的相关岩土体的工程地质特征与场地水文地质特征,据此对分级子坝加高的工程地质条件进行了适宜性评价,并通过对堆积灰体物理力学试验分析了粉煤灰灰体的堆积特征与压实程度,为子坝加高设计提供了可靠参数.     

连续流态下好氧颗粒污泥的培养及处理制药废水的性能

在上流式好氧颗粒污泥床反应器中, 以厌氧颗粒污泥和好氧絮状活性污泥为接种泥, 采用人工配制的模拟废水, 成功培养出性能优异的好氧颗粒污泥.反应器内污泥浓度稳定在5g/L左右, 颗粒污泥粒径为0.5~2.0mm, 当进水COD为2000mg/L, 容积负荷为4.8kg/(m3·d)时, 系统对COD的去除率稳定在96%以上.通过扫描电镜观察, 好氧颗粒污泥是层状结构, 表面有大量丝状菌缠绕, 内部有短杆菌和空穴存在.逐步提高制药废水在进水中的比例, 经过47d的培养, 生物制药废水完全取代模拟废水, 系统对COD、NH₃-N、TP的去除率分别稳定在90%、90%和70%以上.