New Organic Montmorillonite Preparation: Anion-Nonionic Surfactants Modified Montmorillonites

Montmorillonites (MMT) was modified with nonionic surfactant Trion X-100 (OP-10) and anionic surfactants sodium stearate (SSTA) and sodium dodecyl benzene sulfonate (SDBS) respectively. In this study, the effects of anionic surfactant types and MMT types on modification montmorillonite were investigated. XRD analysis results showed that SSTA/OP-10/MMT and SDBS/OP-10/MMT were successfully obtained. The basal spacing of SSTA/OP-10/MMT reached 5.07nm and the SSTA intercalation reaction was relatively stable. Different types of MMT (Xinjiang natural sodium montmorillonite(MMT-1), Jianping sodium montmorillonite (MMT-2) and artificial sodium montmorillonite(MMT-3)) were modified with SSTA/OP-10. XRD test results showed that MMT-1, MMT-2 and MMT-3 can be modified by SSTA/OP-10. Anion-nonionic organic montmorillonite (SSTA/OP-10/MMT-1, SSTA/OP-10/MMT-2 and SSTA/OP-10/MMT-3 were successfully obtained respectively. The higher expansion capacity was found to be beneficial to organic modification.     

改性膨润土去除水溶液中Cr^6＋的性能研究

文章研究了pH值、改性剂用量和改性时间对聚合氯化铝改性膨润土去除水溶液中Cr^6＋效率的影响。实验结果表明：（1）在不同pH值条件下改性得到的聚合氯化铝改性膨润土对水溶液中Cr^6＋的去除效果明显不同。在80℃反应5 h制得的聚合氯化铝改性膨润土,在pH值=7的中性条件下改性得到的改性膨润土对水溶液中Cr^6＋（取0.5g聚合氯化铝改性膨润土处理5mg/L重铬酸钾溶液100ml）的去除率达到最大值（98.35%）。（2）改性剂用量对聚合氯化铝改性膨润土去除水溶液中Cr^6＋影响很大。当pH值=7,在80℃反应5 h的条件下改性膨润土,改性剂聚合氯化铝选用13mmol/g膨润土为宜。（3）改性时间对聚合氯化铝改性信阳膨润土去除Cr^6＋有一定的影响。当改性剂的用量为15mmol/g,pH值=9,反应温度为80℃条件下,最佳改性反应时间是4 h。     

Composite modification mechanism of cationic modifier to amphoteric modified kaolin and its effects on surface characteristics

In this study, the changes of S _DC curves (sum amount of dodecyl trimethyl ammonium cation and Ca²⁺/2 adsorbed on dodecyl dimethyl betaine-modified kaolin under different dodecyl trimethyl ammonium cation molar fractions) were analyzed to reveal the modification mechanism of cationic modifier (dodecyl trimethyl ammonium bromide) on amphoteric modified kaolin (kaolin modified by dodecyl dimethyl betaine). In addition, total organic carbon content and surface characteristics of different modified kaolins were analyzed using X-ray diffraction, specific surface area calculation, Fourier transform infrared spectroscopy, thermogravimetry, and scanning electron microscope. Results showed that: (1) “S _DC” curves of compositely modified kaolin with dodecyl dimethyl betaine-modified ratios of 15, 30 and 60 % started to rise (appeared hydrophobic binding) at dodecyl trimethyl ammonium bromide-modified ratios of 16.80, 7.63, and 0.68 % (the critical point for different modification mechanisms), respectively. (2) Total organic carbon content of modified kaolins under different modification mechanisms showed hydrophobic modification mode > ion exchange and hydrophobic binding coexisting mode > ion exchange mode. Interlayer spacing showed no significant change under different modification modes. Specific surface area decreased slowly with enhanced hydrophobic modification mode. Fourier transform infrared spectroscopy and thermogravimetry results showed the modification effects of both dodecyl dimethyl betaine and dodecyl trimethyl ammonium bromide modification on kaolin surfaces. Scanning electron microscope results presented that the number of lamellar structures increased on clay surfaces with enhanced hydrophobic modification mode.     

煤层气欠平衡水平井的井眼清洁监测方法

为改善植物胶资源日益枯竭对含煤地层等复杂地层冲洗液应用带来的不利影响,对瓜尔胶进行复配−交联改性研究。以黄原胶为复配增效剂,有机硼为交联改性剂,并辅以交联控制剂、无机处理剂,研发一种新型植物胶冲洗液(GXB),并对其进行一系列的性能评价。评价结果表明,GXB性能优良,能够满足含煤地层等复杂地层的钻进需求。采用红外光谱分析、黏度分析、核磁共振分析相结合的方法对其复配−交联改性机理进行分析。结果表明：(1)复配增效过程存在2种作用机制：首先瓜尔胶中无半乳糖分布的区域可与黄原胶分子产生氢键或范德华力嵌合形成三维网状结构以增黏;同时在瓜尔胶作用下黄原胶易发生自缔合以提升体系结构黏度。(2)有机硼中的硼酸根离子主要通过络合半乳糖上的羟基以发生交联反应,体系黏度得到进一步提升,其过程可分为起始期、过渡期、上升期、稳定期4个阶段,各阶段交联反应的快慢主要受有机配位体释放硼酸根离子的速度影响。研究成果为解决含煤地层垮塌难题提供新的解决方案,同时对植物胶冲洗液的改性研究具有一定的参考价值。

     

金云母结构修饰及有机改性实验

用酸处理及热处理+钠化综合方法,对金云母进行了结构修饰,得到具有低剩余层电荷的金云母,用十六烷基三甲基溴化铵(HDTMAB)对结构修饰金云母进行了有机插层改性。利用X射线衍射、化学成分分析、差热等方法对制得的样品进行了表征。研究了硝酸用量对金云母层间剩余负电荷的影响。结果表明,随着硝酸用量的增加,金云母阳离子交换容量和层间剩余负电荷逐渐减小;硝酸用量也影响有机分子在金云母层间的插层行为,当硝酸用量为100 mL时,有机分子烷基链在层间呈双层倾斜排列;当硝酸用量为150 mL时,烷基链在层间呈单层倾斜排列。     

混炼挤压改性对膨润土分散影响的试验研究

通过对天然钙基膨润土钠化改性过程以及有机改性过程中混炼挤压的实验,分析了混炼挤压对膨润土分散的影响。实验结果表明,混炼挤压作用可以有效地提高钙基膨润土的钠化度以及膨润土颗粒的分散度和ξ电位。     

胶束电动毛细管色谱法测定海底表层沉积物中的苯系化合物

用胶束电动毛细管色谱法对海底表层沉积物中的苯系化合物进行了分析测定。采用57cm×50μm毛细管柱,以50mmol/L十二烷基硫酸钠-2.0mmol/L四硼酸钠溶液（pH9.16）作为操作缓冲溶液,并加入φ=20%的甲醇作为有机改性剂,电压25kV,检测波长200nm,15min内苯、甲苯、乙苯和二甲苯可获得良好的分离。用峰面积定量,线性范围为2～100mg/L,最小检测浓度分别为0.75mg/L苯,0.45mg/L甲苯,0.39mg/L乙苯,0.1mg/L邻-二甲苯,0.31mg/L对-二甲苯。将该法用     

铁细菌培养过程中低分子有机酸钠盐对含硫酸根铁矿物形成的影响

普遍存在环境中的低分子有机酸盐对氧化亚铁硫杆菌的矿化产物(施氏矿和黄钾铁矾等铁矿物)会产生影响,从而导致环境中有毒重金属迁移转化发生变化.本文探讨了低分子有机酸钠盐对铁细菌HX3成长过程中代谢产物铁矿物的影响,并利用XRD、FTIR、FESEM和EDS对形成的铁矿物进行了表征与分析.研究结果表明,低浓度低分子有机酸钠盐...     

用于有机废水处理的改性膨润土的制备新方法研究

提出一套不同于传统工艺的有机化膨润土制备方法,并首次采用COD(化学需氧量)与XRD(X射线衍射)双重指标衡量有机化膨润土的合成效果。COD测试表明,选择合适的改性剂种类和用量,是制备废水处理用有机化膨润土的两个前提。XRD分析说明,新工艺制备的有机化膨润土中蒙脱石的d001明显增大,有机改性剂长链分子已经插入蒙脱石矿物层间,合成效果良好。新的有机化膨润土合成工艺省去了过滤、洗涤、烘干、粉碎等步骤,能耗大大降低,成本优势明显,能够有力地促进有机化膨润土在废水处理领域的规模化应用。     

膨润土的有机改性及其钻井液性能

以过硫酸钾为引发剂,通过水溶液聚合法制得了丙烯酸和丙烯酰胺的聚合物A。用聚合物A作为有机改性剂,采用混炼挤压法制备得到样品。用X射线衍射(XRD)、红外光谱(FT-IR)、扫描电子显微镜(SEM)等方法对其结构形貌进行研究。结果表明,其晶面间距由原来的1.269 nm增大到1.322 nm,有机基团进入层间,并且仍保持层状结构,成功制备出了有机改性膨润土。用有机改性膨润土配制钻井液,当其质量分数为4%时,浆液的粘度为5.5 mPa.s,滤失量为13 mL,润滑系数为0.13。与普通钠基膨润土钻井液相比,有机改性膨润土钻井液的滤失量和润滑系数均有较大幅度降低,并且改善了钻井液的流变性。     

基于黏性土分散机制的分散性土化学改性研究

分散性土具有遇水易分散的特性,可导致堤坝等水利工程的冲蚀破坏。基于黏性土分散机制的研究,选用AlCl3• 6H2O、MgCl2•6H2O、CaCl2及CaO作为分散性土的化学改性材料,采用针孔试验和碎块试验对其改性效果进行判别和比较。试验表明,上述改性材料均可将分散性土改性为非分散性土,显著提高土体的抗冲蚀能力。结果说明：在分散性土中掺加高价态阳离子的可溶性盐,通过置换土粒表面钠离子或降低土体碱性,减小颗粒扩散层的厚度,可抑制土体的分散性,从而达到改性的目的;根据黏性土分散机制以及改性试验结果,提出了分散性土化学改性的原则,即改性材料中含有高价态的可溶性阳离子,或改性材料呈酸性,且环境友好,价格低廉,施工方便。     

Crystallisation of sodium sulfate: supersaturation and metastable phases

Crystallisation of sodium sulfate solutions by evaporation under controlled climatic conditions has revealed the existence of crystalline hydrated sodium sulfate salts not previously reported. The sodium sulfate phase crystallising and the concentration of the solution at the point of crystallisation depends on the climatic conditions (temperature and evaporation rate). During the rehydration of the anhydrous sodium sulfate phase, thenardite, another previously unreported phase was formed prior to the nucleation of the stable phase, mirabilite Na₂SO₄ · 10H₂O. The addition of organic inhibitors changes both the crystallisation and the rehydration behavior in this system.     

有机膨润土制备条件对其吸附有机污染物性能的影响

以溴化十六烷基三甲铵为改性剂，对天然钙基膨润土进行有机化改性，系统地研究了改性剂用量以及钠化，热活化和酸活化对有机膨润土吸附苯酚、苯胺、苯、甲苯和二甲苯的影响，并初步探讨了有机膨润土与有机物间的作用机理。实验结果表明，改进剂用量是影响有机膨润土对有机物吸附性能的主要因素；改性剂用量相同时，钠化土的吸附效果明显好于直接改性的6.0%土，而热活化和酸活化对于有机膨润土吸附不同的有机物时影响程度也不同。应用有机膨润土建造垃圾填埋场防渗衬层具有一定的可行性。     

Treatability of resin effluents by electrochemical oxidation using batch recirculation reactor

Electro oxidation processes are developed throughout the world for ambient temperature destruction of organic wastes. Several of these processes are based on mediated electrochemical oxidation. This article presents the experimental results of electro chemical study based on mediated electrochemical oxidation process conducted for synthetic organic ion exchange resin materials. Investigation was carried out using the traditional noble metal oxide coated anode, ruthenium oxide-titanium and the mediator used for the experiment was ferrous sulphate, with sodium chloride as supporting electrolyte. The concentration of sodium chloride was maintained at 5, 8, 12 gm/L. The experiment was carried out in batch recirculation reactor with varied current densities for various flow rates. The study highlighted that in batch reactor set up the best effect of total organic content reduction was found to occur at 3.75 A/dm² with flow rate of 20 L/h. The simulated studies were carried out for different volumes of effluent and current densities. A graphical analysis was made between the experimental and simulated values and it was found that both the values are very close.     

剥片高岭土的有机改性

用醋酸钾进行插层形成高岭土—醋酸钾复合体。通过X射线检测，高岭土层间距明显增大。将此复合体通过水洗，除去醋酸钾，高岭土即被剥片。剥片后高岭土粒径变小，但保持了高岭土的基本层状结构。用偶联剂对剥片后高岭土进行有机改性，形成高岭土有机复合物。“有效活化指数”的测定实验表明，利用此种方法制备的剥片高岭土有机改性效果很好。     

无水砂层大断面矩形管廊顶管施工渣土改良试验

大断面矩形管廊在无水砂层中顶进施工时,由于砂土流塑性差,掌子面易出现“闭塞”、“喷涌”和“结饼”等不良现象,进而影响施工进度。本文以北京市通州区畅和西路(兆善大街-潞阳大街)大断面矩形顶管施工为工程依托,开展了掌子面渣土改良试验研究。以不同配比的钠基膨润土、聚丙烯酰胺(PAM)和水作为砂土改良的添加剂,并通过黏度试验和滤失试验对不同配比的改良剂(膨润土添加聚丙烯酰胺)的性能进行了研究,结合改良后渣土的坍落度试验、直剪试验与压缩试验,评价了掌子面渣土的改良效果。研究表明:膨润土添加聚丙烯酰胺对无水砂层的改良效果显著。通过改良剂性能试验,初步筛选出膨润土: PAM: 水为60:2:1000,70:1.5:1000,70:2:1000和80:1.5:1000等4种性能优良的改良剂配比;通过渣土改良效果试验得出,改良剂最优配比膨润土: PAM: 水为70:2:1000,改良剂最优注入比为15%;通过添加改良剂使得改良后渣土的坍落度降低30 mm,黏聚力增加9.3 kPa,内摩擦角降低6.5°,压缩系数增加0.090 MPa-1,达到了无水砂层土体处于流塑性状态的预期效果,有效降低了大断面矩形管廊侧壁阻力,提高了顶进效率。     

Distribution and nature of incorporation of trace elements in modern aragonitic corals*

The objective of this study is to locate as closely as possible the sites of strontium, magnesium, sodium, and potassium in modern aragonitic corals, specifically whether these cations are adsorbed, or are substituted in the carbonate lattice or are incorporated in organic components. In addition to locating the sites of each of these four elements we wanted to find out quantitatively how much of each element occurs at each site. The experiments in this study are based on the dissolution rate of aragonite in distilled water and on the substitution of strontium and magnesium by calcium and sodium. Special attention has been given to the occurrence of strontium, magnesium, sodium, and potassium in the organic components of the corals. The main site for strontium in the corals is in the aragonite lattice. Twenty-five per cent of the total magnesium occurs in adsorbed sites and in organic compounds. The rest of the magnesium may be located in the aragonite lattice, but it is easily removed by repeated leaching or by replacement with calcium ions. Another possibility is that magnesium may occur in a dispersed mineral phase more soluble than aragonite because magnesium was released at a higher Mg to Ca ratio than is found in the solid coral; also because no local concentration of magnesium could be detected with an electron microprobe. About 12% of the total sodium is in adsorbed sites and is included in the organic compounds. The rest of the sodium might be in the lattice replacing calcium, but the low total exchange capacity is not enough to provide the needed charge balance. Another possibility is that sodium is located in a proposed mineral phase. Potassium is in adsorbed sites and incorporated in the organic compounds to an extent greater than all the other elements studied (30% of the total potassium), but again the evidence suggests that the remaining potassium is in a proposed mineral phase. Calcite is detected on the surfaces of aragonite corals after 5 months in the substitution experiment. The change of argonite to calcite took place after the inhibitor magnesium was exchanged from the surface sites and replaced by calcium. The organic compounds in corals contain small amounts of strontium, magnesium, sodium and potassium. Strontium is preferentially enriched in the organic compounds over magnesium.     

累托石改性的研究进展

累托石作为一种具有优良物化性能的铝硅酸盐矿物,近年来在开发利用方面有了创新性进展,本文在综述前人研究成果的基础上,介绍了累托石的成分、结构等特征,概述了累托石钠化改性、有机改性、无机柱撑改性的研究进展,同时总结了目前累托石改性存在的问题,并对累托石的改性研究前景进行了展望.     

新型高分子改性剂的合成及含电气石功能聚合物的制备

采用丁二酸酐和乙酸乙烯酯进行共聚,制备了含有酸酐活性基团的高分子聚合物P(SA-VA);然后用该活性聚合物对电气石进行表面改性,制备了含电气石的功能聚合物。通过IR、XRD、SEM等对改性产物结构和形貌进行了表征。实验结果表明,P(SA-VA)的酸酐基团与电气石表面的羟基发生了反应,电气石粉体被成功地引入到共聚物中,得到了含电气石的功能聚合物。该功能聚合物具有优良的分散性和储存稳定性,且该含电气石的功能聚合物成膜后具有良好的力学性能和优异的负离子释放量、远红外辐射等性能。     

交换液酸碱度对OTAC在蒙脱石中吸附及复合物凝胶粘度影响

在蒙脱石有机改性体系中,交换液酸碱度对蒙脱石荷电性以及十八烷基三甲基氯化铵(OTAC)的电离度影响很大,进而影响OTAC在蒙脱石中的吸附以及制备复合物的凝胶粘度。研究发现,在pH=3的强酸性交换体系中,蒙脱石端面可变电荷为正电荷,OTAC阳离子和蒙脱石之间静电斥力的存在不利于OTAC在蒙脱石上的吸附,吸附量和吸附率分别是0.943CEC和85.7%,制备复合物的凝胶粘度最低,分别是μ0min为45.67Pa·s,μ30min为16.52Pa·s;在pH=10的弱碱性交换体系中,由于蒙脱石层面和端面均带有负电荷,静电引力更有利于OTAC阳离子在蒙脱石层间交换及表面吸附,其吸附量和吸附率最高,分别为1.097CEC和99.71%,制备复合物的凝胶粘度也较高,分别是μ0min为95.93Pa·s,μ30min为37.67Pa·s;在强碱性交换体系中,当pH=11和13时,蒙脱石对OTAC的吸附量和吸附率降低明显,吸附量分别为1.08CEC和1.058CEC,吸附率分别降到98.20%和96.18%,对应复合物的μ0min分别为96.52Pa·s和93.52Pa·s,μ30min分别为36.57Pa·s和36.53Pa·s,究其原因由于交换液中OTAC阳离子和高浓度的钠离子在蒙脱石层间和表面存在竞争吸附导致蒙脱石层间钠离子的交换难度加大。