Model Test Study on Ice Induced Vibration of A Compliant Conical Structure

1.Introduction Inthedesignofoceanengineeringstructuresforcoldregioncountries,iceloadsarealwaysthe controlloads,andthedesignofice resistingstructuresisoneoftheimportantdesignaspects.Fornat uralseaice,theflexuralstrengthisalwaysonethirdofthecompressivestrength.Soconicalstructures thatcouldinducethebendingfailureoficesheetsarewidelyusedinthedesignsofice resistingstruc tures.Forexample,theplatformKullukintheBeaufortSeaisaninvertedconicalstructure,andan upward downwardbendingconeisusedonplatformJ…     

Model Test Study on Ice-Induced Vibrations of Compliant Multi-Cone Structures

For the study on the ice-induced vibration of a compliant mono-cone structure,a series of model tests were performed from 2004 to 2006.In these tests,the ice sheet before the compliant conical structure was found to be failed in two-time breaking.Based on this important finding,model tests study of the ice force on a compliant multi-cone structure were performed from 2006 to 2007.in these tests,the ice sheet broke before each single cone non-simultaneously.The exciting energy of the total ice force was found to be in a wide range of frequencies,and the structure can be easily excited with nonlinear resonance.     

锥体冰力的实验研究

通过冰力模型试验,研究了锥体冰力的特征和锥间距对冰力的影响。试验发现冰在正-倒锥交界线上的破坏为挤压破坏;根据试验数据给出了冰在双锥前的非同时破坏系数。     

锥角对锥体结构抗冰性能影响的离散元分析

在寒区海洋工程中,锥体海洋结构的尺寸参数对其破冰性能具有重要影响。采用具有黏结-破碎功能的离散元方法模拟海冰与锥体结构的相互作用过程中海冰的破坏模式及冰载荷分析。该离散元方法的计算参数通过与渤海油气平台的实测数据对比进行了可靠性验证。在此基础上,当设计海域的潮差固定时,对不同锥角下风电单桩锥体结构的冰载荷和海冰破坏模式进行了离散元分析。计算结果表明:锥体冰载荷随锥角的增大而增大,海冰的平均断裂长度则随锥角的增大而减小;当锥角小于70°时海冰的破碎模式主要为弯曲破坏,而当锥角大于70°时海冰破坏模式则主要为挤压破碎。以上研究结果可为冰区海上风电单桩结构的抗冰锥设计提供参考。     

A New Model for Ice Forces on A Conical Structure

The ice force is an important factor to be taken into account for offshore structures in cold regions, and the calculation method of the ice force is meaningful for the offshore structure design. The cone is now used as an optimal ice-resistant structure because it can cause bending failure of the ice sheet. The interaction between an ice sheet and a conical structure is studied in this paper and Croasdale‘s model is modified based on field observations. The newly built model separates the ice sheet into the emersed part and the floating part, and the equilibrium analyses are canied out respectively. The bending moment distribution of the ice sheet is analyzed for the determination of the position of bending failure, which serves as a supplementary restraint. The analytic solution of the ice foree on a conical structure is obtained it is verified with the experimental data of previous researches.     

渤海抗冰导管架平台失效模式分析

基于多个现役结构的监测数据,对渤海抗冰导管架平台的动力失效进行了分析。结果显示,渤海抗冰导管架平台属于典型的柔性抗冰结构,存在比较显著的冰激振动现象,冰振不仅能引起显著的导管架管结点疲劳应力,还会激起较大的甲板加速度响应,引起作业人员与上部设施的疲劳问题。     

正倒锥体结构上冰力谱分析实验研究

利用研制的新型非冻结可破碎合成模型冰材料，进行了冰排与正倒锥体结构物作用的物理模拟试验研究，试验中观察记录了冰排的破碎过程并测定了作用于锥体结构物上的冰力，通过快速傅立叶变换方法由所测得的冰力时程曲线得到冰力频谱，分析并讨论了冰排速度，本结构物的水线直径，锥角以及冰排弯曲破坏方向等对冰力频谱对冰力频谱因子的影响。     

Investigations of ice forces on a conical offshore structure

Conical shapes have been used for a long time to reduce the ice impact forces. For a major Canadian offshore lighthouse in Lake Erie, a nearly conical shape was used as early as 1857. But the actual mode of destruction of an ice sheet colliding with a conical structure is still not fully understood. The measured and theoretical values of the horizontal force calculated by the different methods have been compared. Calculations and field observations suggest that a failure mode transitional between that of crushing and flexure occurs for the steeper cone angles.     

大直径单桩风机基础冰荷载模型试验研究

针对渤海某海域以单桩结构为支撑的海上风电系统,对大直径直立桩风机基础进行了一系列静冰载荷模型试验研究。首先,针对目标海域海冰调研结果确定多个冰速工况,对3 MW及4 MW装机功率对应的两种不同直径的单桩基础开展静冰载荷模型试验;随后在试验现象及试验结果的分析中重点关注了冰排在大直径结构前的破坏模式及破坏特点;最终,通过对比模型试验冰力极值试验结果与多规范冰载荷计算结果,确定大直径直立桩静冰载荷计算规范的合理选择,并根据试验结果对直立桩静冰载荷计算方法进行了经验参数修正。得出的相关结论可为渤海海域大直径单桩式风机基础冰载荷的工程估算提供参考。     

基于黏聚单元法计算分析海洋平台锥形立柱冰载荷

基于非线性有限元分析方法和LS-DYNA计算软件,使用黏聚单元法建立层冰的数值模型,并进行了层冰与锥形立柱相互作用的数值模拟,研究抗冰锥角、冰厚等参数对立柱所受冰载荷的影响。模拟结果与实测和试验结果吻合良好。研究结果表明:使用黏聚单元法建立的层冰模型可以较好地模拟出层冰的破碎和堆积过程,冰载荷计算结果与ISO冰力标准结果以及离散单元法计算结果吻合较好;锥形立柱的抗冰锥角大小对冰载荷影响明显,随着锥角增大,水平方向的最大冰力增大而竖直方向上最大冰力减小;锥形结构改变了碰撞过程中层冰的破坏形式;结构物所受冰力大小与层冰厚度呈正相关,且增加速度接近线性。     

多桩锥体海洋平台结构冰荷载遮蔽效应离散元分析

在海冰与多桩锥体海洋平台结构的相互作用中,平台结构总冰力在海冰流向和桩腿方位的影响下呈现出显著的遮蔽效应。采用具有粘结-破碎效应的离散元方法,基于GPU并行的高性能计算,对不同冰向下锥体海洋平台结构的冰荷载进行了数值分析,确定了不同冰向下平台结构各桩腿的冰力衰减系数并分析了总冰力的遮蔽效应。最后,对自由边界影响下多桩平台结构冰荷载遮蔽效应的产生机理进行了讨论。本文工作可为多桩腿平台结构的冰荷载特性、冰激结构振动以及冰区结构设计提供参考。     

Non-Simultaneous Failure of Ice in Front of Multi-Leg Structures

Because the multi-leg jacket structure is the major type of offshore structures in the Bohai Sea, the study of non-si-multaneous failure of i鏴 on multi-leg structures is important. However, the non-simultaneous failure has not been consid-ered in engineering design until now, obviously resulting in costly design and notable waste. To resolve this problem, this paper, by means of analysis of experimental data, calculates the coefficient of the non-simultaneous failure for the double-pile structure, the square four-leg structure, the single-line multi-pile structure, and the conical structure, respectively, and provides some reference criteria for engineering design.     

基于黏聚单元法的抗冰海洋平台与层冰相互作用数值模拟

通过商业有限元软件LS-DYNA采用黏聚单元法模拟层冰的断裂问题,在IIHR冰池模型试验相同缩尺比参数下对KULLUK抗冰平台受到的冰力进行数值计算,探究冰厚与冰速等冰况参数对平台冰力的影响。计算结果表明,在极地作业平台主要遭遇北极海域冰况范围下,相同冰厚情况时冰速变化对倒锥形结构平台的横向冰力影响不大,而同冰速时冰力随着冰厚的增加接近线性增加。同时将计算所得结果与同条件下IIHR冰池模型试验数据、ARCTEC、ACL非冻结模型冰试验数据、实船数据和通过ISO19906规范中提供的针对大锥面结构受到层冰冰力的经验公式计算所得数据等进行了对比,验证了选用冰参数的可靠性以及该数值模型在模拟大尺度宽锥形平台遭受层冰作用问题中的适用性。     

Characteristics of the Function of Ice Force on Vertical Cylindrical Piles

A lot of tests on ice forces on vertical cylindrical piles are conducted in the ice basin of ice laboratory in Tianjin University to identify the characteristics of ice forces on fixed platforms in the Bohai Gulf. A function of ice forces is simplified on basis of test data, and the charateristics of the ice forces including the amplitude of the force and the breaking frequency of the ice sheet is detailed by use of the Fast-Fourier-Transform method. The results show that the ice breaking frequency presents a linear relationship with the ratio of ice moving velocity to ice thickness at low velocities. At high velocities, the frequency remains constant with the increase of the ratio of ice moving velocity to ice thickness. These conclusions are compared those published in literature.     

Reliability Analysis of Ice-Induced Fatigue and Damage in Offshore Engineering Structures

—In Bohai Gulf,offshore and other installations have collapsed by sea ice due to the fatigueand fracture of the main supporting components in the ice environments.In this paper presented are someresults on fatigue reliability of these structures in the Gulf by investigating the distributions of iceparameters such as its floating direction and speed,sheet thickness,compressive strength,ice forces on thestructures,and hot spot stress in the structure.The low temperature,ice breaking modes and componentfatigue failure modes are also taken into account in the analysis of the fatigue reliability of the offshorestructures experiencing both random ice loading and low temperatures.The results could be applied to thedesign and operation of offshore platforms in the Bohai Gulf.     

Ice-Induced Fatigue Analysis by Spectral Approach for Offshore Jacket Platforms with Ice-Breaking Cones

The spectral methods and ice-induced fatigue analysis are discussed based on Miner's linear cumulative fatigue hypothesis and S-N curve data.According to the long-term data of full-scale tests on the platforms in the Bohai Sea,the ice force spectrum of conical structures and the fatigue environmental model are established.Moreover,the finite element model of JZ20-2MSW platform,an example of ice-induced fatigue analysis,is built with ANSYS software.The mode analysis and dynamic analysis in frequency domain under all kinds of ice fatigue work conditions are carried on,and the fatigue life of the structure is estimated in detail.The methods in this paper can be helpful in ice-induced fatigue analysis of ice-resistant platforms.     

冰对锥体结构作用力的预测模型分析

通过对作用在锥体结构上的各种静冰力预测模型的介绍,根据大量实验室模拟测试数据,运用直方图对比、无量纲效应分析及统计分析等手段,对有关静冰力计算公式进行了全面分析与确认.所采用的分析方法为我国渤海辽东湾JZ20-2平台原型冰荷载测试数据与预测模型的比较,为利用原型观测数据建立适合于我国渤海环境条件下冰对锥体结构作用力预测模型,提供了有效的技术手段,同时也为有冰海域结构物的可靠性分析提供了各统计量有价值的参考数据.     

海冰与直立结构相互作用的破坏模式研究

海冰在结构前的破坏模式以及产生的冰载荷与结构尺度和海冰厚度密切相关。采用海冰离散元方法（DEM）模拟平整冰与直立结构相互作用过程中的海冰破坏模式及整体冰载荷。该离散元方法的计算参数通过与Norstr?msgrund灯塔的现场实测数据对比进行了可靠性验证。在此基础上,对不同宽厚比（结构宽度与海冰厚度的比值）工况下平整冰与直立结构作用过程中的海冰破坏模式和整体冰压力进行了离散元分析。模拟结果表明：当宽厚比＜10时,海冰破坏模式主要为挤压破坏;当10≤宽厚比＜30时,海冰混合破坏发生;当宽厚比≥30时,海冰屈曲破坏发生。从海冰断裂长度与平均冰压力两个方面进一步说明了海冰破坏模式的转变过程。最后,构建了直立结构极值冰压力计算公式。研究成果可为寒区直立结构的整体设计提供参考。     

冰激锥体振动物理模拟实验

应用DUT 1非冻结可破碎模型冰进行冰激锥体振动模拟实验的实验设备和模型的设计 ,给出了低冰速和高冰速两种情况下的结构位移曲线、冰力曲线及其幅值谱分析结果 ,得出了结构卓越频率和冰速与特征长度之比的关系 ,发现冰激锥体振动同冰激柱体振动一样有“频率锁定”现象。将实验结果与已有的冰排与圆柱相互作用实验结果进行比较 ,发现冰激锥体振动和冰激柱体振动有着相似的机理     

基于水下光纤应变监测的导管架结构总冰力测量方法

基于测量结构水下光纤应变获取冰力的方法首次应用于渤海JZ20-2NW加锥导管架平台,该方法方便进行零点标定,可获取结构总冰力的绝对信息(包括均值和波动值)。首先介绍了JZ20-2NW平台的现场监测系统,主要包括结构水下应变响应记录冰力信息,甲板上部视频记录同步冰情(冰厚、冰速和来冰方向)信息和拾振器记录结构冰振响应;重点分析了由测点应变向结构总冰力的转化方法,并对总冰力进行了初步分析。将无量纲化实测冰力与5种典型冰力计算模型进行了比较,分析结果表明,锥体宽度与海冰厚度比值(简称"宽厚比")对冰力大小及变化起决定作用。